Clymer Kawaski Personal Watercraft Manual

Clymer Kawaski Personal Watercraft Manual
- Whether it is simple maintenance or complete restoration, do not start work without Clymer, the leader in service manuals
Kawasaki Jet Ski, 1992-1994
Part #: W802

488 pages

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational check list / Lubrication / Recommended fuel mixture / Fuel mixing / Starter gear oil / Control cable lubrication / Periodic maintenance / Fuel vent check valve inspection / Oil tank vent valve / fuel filter / Flame arrester / Impeller / Rubber coupler / On-shore cooling / Steering cable adjustment / Trim cable adjustment / Throttle cable adjustment / Choke cable adjustment / Engine tune-up / Retorque cylinder head / Compression test / Spark plug / Ignition timing / Carburetor adjustment / Fuel mixture screw initial setting / Fuel mixture adjustment / idle speed / Carburetor synchronization / Storage / Specifications

CHAPTER FOUR / ENGINE (440 AND 550 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Removal installation / Engine top end / Cylinder / Piston, pin and rings / Crankcase and crankshaft / Specifications
CHAPTER FIVE / ENGINE (650 AND 750 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing the engine in the hull / Engine / Engine top end / Cylinder / Piston, pin and rings / Reed valve assembly / Crankcase and crankshaft / Water drain valve / Starter reduction gear / Specifications

CHAPTER SIX / DRIVE TRAIN
Drive shaft / Jet pump / Reverse system / Specifications

CHAPTER SEVEN / FUEL AND EXHAUST SYSTEMS
Flame arrestor / Mikuni carburetor / Keihin carburetor / Fuel pump / Fuel tank / Main fuel valve / Exhaust system / Exhaust system cleaning and inspection / Specifications

CHAPTER EIGHT / ELECTRICAL SYSTEMS
Battery / Charging system / Electric starting system / Capacitor discharge ignition CDI / RPM limiter / Electric box / Bilge pump test /
Country USA
Brand Clymer
Manufacturer Clymer
Binding Apparel
ItemPartNumber 27-W802
Model 27-W802
Warranty Manufacturer
Color Red
ReleaseDate 2010-08-21
UnitCount 1
UPCs 024185764410
EANs 0024185764410

Country	USA
Brand	Clymer
Manufacturer	Clymer
Binding	Apparel
ItemPartNumber	27-W802
Model	27-W802
Warranty	Manufacturer
Color	Red
ReleaseDate	2010-08-21
UnitCount	1
UPCs	024185764410
EANs	0024185764410

Clymer Kawaski Personal Watercraft Manual

Customers who purchased this also purchased....